View Single Post
Old 13-06-2009, 12:35 AM   #1
asanga
Senior Member
 
asanga's Avatar
 
Join Date: Dec 2006
Location: Sutherland Sydney
Car: astina BA 1997 1.8Ltr
Posts: 609
HOW TO : Replace lower arm ball joints of BA Astina (lots of pics!!)

I replaced the ball joints recently due to torn rubber boot and thought I'll post the method I used. Its very straight forward and doesn't need much tools. I'm pretty sure most ppl here have done this but for those who haven't this might be a guide and you'll save $$$ if you do it your self!!.

1. Jack the car up (which ever the side you are going to replace) and secure using jack stands. Never trust a hydraulic jack it can fail without a warning and it has happened to me once!



2. remove the wheel

3. Remove the nut on the top side of the arm as shown in pic (17mm socket), expect this to be very tight!



4. Remove the nut on the bottom side as shown in pic (17mm socket), again this will be very tight.



5. remove the nut and pull the bolt out completely to release the pin of the ball joint. Tap it lightly or pry open using a screwdriver if it doesn't fall off easily.



After removing the ball joint


The new part


Comparison (there was sand, water, dirt etc mixed with grease inside the damaged boot and it was making a noise when cornering/breaking)



6. Place the new ball joint (installation is reverse order of removal).

You may need to use the jack to lift the lower arm up to assist with alignment.(if you don't have an assistant to help)



All done!!


Repeat this process for other side as well!

Good luck!
asanga is offline   Reply With Quote
Sponsored Links